filename: tfs 92b.doc version 1.2 03.05.2006 vi telefilter filter specification tfs 92b 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. measurement condition ambient temperature: 23 c input power level: 0 dbm terminating impedance: * input: 2530 ? || -8,1 pf output: 2380 ? || -9,4 pf characteristics remark: the reference level for the relative attenuation a rel of the tfs 92b is the minimum of the pass band attenuation a min . the minimum of the pass band attenuation a min is defined as t he insertion loss a e . the centre frequency f c is the arithmetic mean value of the upper and lower frequencies at the 3 db filter attenuation level relative to the insertion loss a e . the temperature coefficient of frequency tc f is valid for both the reference frequency f c and the frequency response of the filter in the operating temperature range. d a t a typ. value tolerance / limit insertion loss a e 11,3 db max. 15 db (reference level) nominal frequency f n - 92,0 mhz centre frequency f c 92,01 mhz - passband pb f n 500 khz pass band ripple 0,4 db max. 0,8 db amplitude ripple in any 112,5 khz segment within pb p-p 0,2 db max. 0,5 db relative attenuation a rel f n ? f n 500 khz 0,4 db max. 0,8 db f n 1,1 mhz ? f n 1,5 mhz 47 db min. 39 db f n 1,5 mhz ? f n 3 mhz 48 db min. 40 db 0,3 mhz ? f n - 3 mhz 60 db min. 50 db f n + 3 mhz ? f n + 1 ghz 65 db min. 50 db group delay at f n 2,3 s max. 4 s group delay ripple in any 112,5 khz segment within pb 60 ns max. 120 ns phase linearity in any 112,5 khz segment within pb p-p 1,4 deg max. 5 deg triple transit response suppression 38 db min. 35 db input power level - max. 23 dbm**) operating temperature range otr - - 40 c ... + 70c storage temperature range - - 40 c ... + 100c frequency inversion temperature 15 c - temperature coefficient of frequency tc f ** -0,036 ppm/k 2 - *) the terminating impedances depend on parasitics and q-values of matching elements and the board used, and are to be understo od as reference values only. should there be additional questions do not hesitate to ask for an application note or contact our design team. **) this power level is only allowed for short term operation (10% of the life time), the max. input power for continuous opera tion is max.15dbm only ***) ? f(hz) = tc f (ppm/k 2 ) x (t-t 0 ) 2 x f to (mhz) generated: checked / approved:
filename: tfs 92b.doc version 1.2 03.05.2006 vi telefilter filter specification tfs 92b 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. filter characteristic construction and pin connection (all dimensions in mm) date code 6 5 10 19 -0,10 + 0,20 6,50 -0,10 + 0,20 1 2,0 max. 1,91 7,62 2,31 1,02 1 50 ohm test circuit tfs 92b u18 1 input 2 ground 3 ground 4 ground 5 output 6 output 7 ground 8 ground 9 ground 10 input date code: year + week u 2006 v 2007 w 2008 ... 82 84 86 88 90 92 94 96 98 100 102 -70 -63 -56 -49 -42 -35 -28 -21 -14 -7 0 frequency in mhz magnitude in db 91.25 91.4 91.55 91.7 91.85 92 92.15 92.3 92.45 92.6 92.75 -10 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 frequency in mhz magnitude in db 91.25 91.4 91.55 91.7 91.85 92 92.15 92.3 92.45 92.6 92.75 2.16 2.25 2.34 2.43 2.52 2.61 2.7 2.79 2.88 2.97 3.06 frequency in mhz delay in s l1 l2 c1 saw 1 5 2, 3, 4, 7, 8, 9 6 10 l3 l4 c2
filename: tfs 92b.doc version 1.2 03.05.2006 vi telefilter filter specification tfs 92b 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. stability characteristics, reliability after the following tests the filter shall meet the whole specification: 1. shock: 500g, 1 ms, half sine wave, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely, 1 octave per min, 10 cycles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cycles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; this filter is rohs compliant (2002/95/eg, 2005/618/eg) packing tape & reel: iec 286 ? 3, with exception of value for n and minimum bending radius; tape type ii, embossed carrier tape with top cover tape on the upper side; max. pieces of filters per reel: 2000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm so w do po e ct p2 p1 d1 bo ao pull off direction type pin marker date code t ko n w 2 w 1 a c the minimum bending radius is 45 mm. tape (all dimensions in mm) w : 32,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 14,20 0,1 p2 : 2,00 0,1 p1 : 12,00 0,1 d1(min) : 2,00 a o : 7,10 0,1 bo : 19,60 0,1 so : 28,40 0,1 ct : 25,5 0,1 reel (all dimensions in mm) a : 330 w1 : 32,4 +2/-0 w2(max) : 38,4 n(min) : 100 c : 13,0 +0,5/-0,2
filename: tfs 92b.doc version 1.2 03.05.2006 vi telefilter filter specification tfs 92b 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. air reflow temperature conditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c between 300 and 600 seconds > 150c between 240 and 500 seconds > 217c between 30 and 150 seconds peak temperature max. 260c time within 5c of actual peak temperature between 10 and 30 seconds cool-down rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds temperature / c time / s max. 260c 217c 10 ... 30 s 30 ... 150 s max. 300 s chip-mount air reflow profile
filename: tfs 92b.doc version 1.2 03.05.2006 vi telefilter filter specification tfs 92b 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. history version reason of changes name date 1.0 - generation of development specification strehl 18.10.2005 1.1 - change relative attenuation strehl 15.11.2005 - change ?stability characteristics? to ?stability characteristics, reliability? 1.2 - terminating impedances, typical values and filter characteristic added pfeiffer 03.05.2006
|
