copyright ?2007 by zilog ? , inc. all rights reserved. www.zilog.com introduction zilog?s ZCRMZN00100KITG crimzon ? development board kit is designed for use as a target with the crimzon in-circuit emulat or (zcrmznice01zemg). the kit is powered by two 1.5 v aaa batteries (see figure 1 ). the development board can also be powered using an adjustable dc power supply connected to input jack j13. this product user guide helps you to install the batteries supplied with the accessory kit and tells how to verify proper development board operation. kit contents the kit contents are listed below: ? one development board w ith no silicon installed ? two 1.5 v aaa batteries applying power to development board follow the steps below to apply batte ry power to the development board: 1. install the two 1.5 v aaa batteries in the battery holder on the bottom of the development board. when installing the batte ries, ensure that the batteries are fully seated in the battery holder by rotating each battery after snapping it into place. 2. set switch sw6 (see figure 1 ) to the battery position. follow the steps below to use an adjustable dc power supply to the development board: 1. set switch sw6 (see figure 1 ) to the external position. 2. connect the adjustable dc po wer supply to jack j13 (see figure 1 ). for more information on using the crimzon development board accessory kit to develop ir applications, refer to the crimzon in-circuit emulator user manual (um0217) . ZCRMZN00100KITG crimzon ? development board kit product user guide pug002601-1207
crimzon ? development board kit pug002601-1207 page 2 of 8 figure 1. crimzon ? development board kit switch sw6 external dc power jack j13
crimzon ? development board kit pug002601-1207 page 3 of 8 figure 2. schematics (1 of 5) 5 5 4 4 3 3 2 2 1 1 d d c c b b a a vbat vbat txd rxd vbat p35_out gnd vbat gnd vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat vbat p31 p36_out p32 p30 p31 p32 p33 p34 p35 p36 p37 p35_out p20 p21 p01 p24 p05 p00 p26 p27 p02 p06 p23 p22 p25 p04 p03 p07 sda scl p07 vbat gnd title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 15 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 15 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 15 monday, august 27, 2007 test points 8-pin pdip socket default: off default: off default: on hdr# name default shunt position j7 j8 tx enable rx enable 1-2 off 1-2 off hdr# name j20 internal ir amp external ir amp 2-4 on shunt position 1-2 on 3-4 on default: 2-4 on r6 6.8k ohm r6 6.8k ohm 1 2 d3 lte-5208a d3 lte-5208a r9 47k r9 47k r4 10k r4 10k 1 2 r14 330 ohm r14 330 ohm d1 ltr-516ad d1 ltr-516ad u2d 74hcu04 u2d 74hcu04 9 8 14 7 c3 0.047uf c3 0.047uf j20 j20 1 2 3 4 u2c 74hcu04 u2c 74hcu04 5 6 14 7 r5 10k r5 10k 1 2 q1 2n3904 q1 2n3904 3 2 1 u1 at24c256 u1 at24c256 a0 1 a1 2 a2 3 gnd 4 sda 5 scl 6 wp 7 vcc 8 r2 10k r2 10k c10 0.1uf c10 0.1uf r8 560 ohm r8 560 ohm j5 hdr/pin 1x1 j5 hdr/pin 1x1 1 c2 3300pf c2 3300pf c6 0.1uf c6 0.1uf c5 0.1uf c5 0.1uf u3 sp3220ebca u3 sp3220ebca c1+ 2 c1- 4 c2+ 5 c2- 6 t1in 11 r1out 9 en 1 shdn 16 r1in 8 t1out 13 v- 7 v+ 3 vdd 15 gnd 14 j3 port 2 j3 port 2 1 2 3 4 5 6 7 8 r1 10k r1 10k d2 red d2 red 2 1 j7 tx j7 tx 1 2 u2b 74hcu04 u2b 74hcu04 3 4 14 7 u2e 74hcu04 u2e 74hcu04 11 10 14 7 j2 hdr/pin 1x2 j2 hdr/pin 1x2 1 2 r11 10 ohm r11 10 ohm r7 10k r7 10k c8 0.1uf c8 0.1uf j1 port 0 j1 port 0 1 2 3 4 5 6 7 8 j6 hdr/pin 1x1 j6 hdr/pin 1x1 1 c4 0.047uf c4 0.047uf r3 2.2m ohm r3 2.2m ohm 1 2 r12 10k r12 10k r13 110k r13 110k j4 port 3 j4 port 3 1 2 3 4 5 6 7 8 c7 0.1uf c7 0.1uf u2f 74hcu04 u2f 74hcu04 13 12 14 7 r10 330 ohm r10 330 ohm j8 rx j8 rx 1 2 p1 db9 fem/rt p1 db9 fem/rt 1 6 2 7 3 8 4 9 5 u2a 74hcu04 u2a 74hcu04 1 2 14 7 c9 0.1uf c9 0.1uf c1 3300pf c1 3300pf
crimzon ? development board kit pug002601-1207 page 4 of 8 figure 3. schematics (2 of 5) 5 5 4 4 3 3 2 2 1 1 d d c c b b a a p00 p01 p02 p03 p04 p05 p32 p31 p34 p33 p06 p07 p00 p20 led2 led3 led4 led5 led6 led7 led8 p24 p34_out vbat gnd p36 p01 p07 xin p25 vbat p26 p27 xout gnd p21 p23 p22 led1 led2 led3 led4 led5 led6 led7 led8 gnd p33 p33 p32 p32 xin xout p31 p34 p34 p30 p36 p25 p26 p04 p27 p07 vbat p06 p05 p22 p20 p00 p21 p03 p23 p01 gnd p02 p24 p22 p20 p24 p21 p25 p23 p27 p26 p32 p33 p31 p30 vbat p37 sda scl vbat gnd led1 p04 p01 p06 p07 p02 p00 p03 p05 p35 scl sda p37 p27 p34 p35 p36 p37 p34_out p35_out p37_out p36_out vbat p34 vbat vbat vbat gnd p00 p01 p02 p03 p04 p05 p06 p07 p37 p31 p32 p33 p34 p35 p36 p22 p23 p26 p27 p24 p25 p20 p21 p32 p30 p33 p31 p35 p36 p37 p34 p34_out p36_out p37_out p35_out scl sda title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 25 monday, september 10, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 25 monday, september 10, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 25 monday, september 10, 2007 default all off 1-2 on 3-4 on default 1-2 on default default all off default all on default off 28pin socket 20pin socket p34 = debug u5 u5 p26 2 p33 10 p32 9 p31 8 p27 3 xtal2 6 vdd 5 p24 20 p25 1 p21 17 p20 16 vss 15 p00/p30 13 p36 12 p34 11 p01 14 xtal1 7 p07 4 p23 19 p22 18 sw3 dip/8pos sw3 dip/8pos y1 8mhz y1 8mhz r19 330 ohm r19 330 ohm j9 led j9 led 1 2 3 4 5 6 7 8 d7 red d7 red 2 1 r22 330 ohm r22 330 ohm r27 10k r27 10k 1 2 d11 red d11 red 2 1 r21 330 ohm r21 330 ohm r18 330 ohm r18 330 ohm sw2 dip/8pos sw2 dip/8pos u4 u4 p25 1 p26 2 p27 3 p04 4 p05 5 p06 6 p07 7 vdd 8 xtal2 9 xtal1 10 p31 11 p32 12 p33 13 p34 14 p35 15 p37 16 p36 17 p30 18 p00 19 p01 20 p02 21 vss 22 p03 23 p20 24 p21 25 p22 26 p23 27 p24 28 r17 330 ohm r17 330 ohm r25 680k ohm r25 680k ohm 1 2 3 4 5 6 7 8 9 10 d6 red d6 red 2 1 d10 red d10 red 2 1 sw4 dip/8pos sw4 dip/8pos r24 680k ohm r24 680k ohm 1 2 3 4 5 6 7 8 9 10 c12 22pf c12 22pf r23 680k ohm r23 680k ohm 1 2 3 4 5 6 7 8 9 10 j11 i2c j11 i2c 1 2 3 4 j12 hdr/pin 1x3 j12 hdr/pin 1x3 1 2 3 r16 330 ohm r16 330 ohm r15 330 ohm r15 330 ohm d5 red d5 red 2 1 d9 red d9 red 2 1 jp1 hdr/pin 2x3 jp1 hdr/pin 2x3 1 2 3 4 5 6 q2 2n3906 q2 2n3906 2 1 3 j10 hdr/pin 2x2 j10 hdr/pin 2x2 1 2 3 4 r20 330 ohm r20 330 ohm sw5 dip/8pos sw5 dip/8pos c11 22pf c11 22pf r26 1k r26 1k d4 red d4 red 2 1 d8 red d8 red 2 1
crimzon ? development board kit pug002601-1207 page 5 of 8 figure 4. schematics (3 of 5) 5 5 4 4 3 3 2 2 1 1 d d c c b b a a vbat vbat gnd gnd vbat title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 35 wednesday, september 12, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 35 wednesday, september 12, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 35 wednesday, september 12, 2007 power supply note: bt1 use battery holder label: external default: on label: battery d12 green d12 green 2 1 r30 121 ohm r30 121 ohm 1 2 sw6 eg1218 sw6 eg1218 1 3 2 r31 332 ohm r31 332 ohm r33 200 ohm r33 200 ohm r29 200 ohm r29 200 ohm 1 3 2 j21 hdr/pin 1x2 j21 hdr/pin 1x2 1 2 j13 pj-007 j13 pj-007 1 2 3 j14 vbat j14 vbat 1 2 3 + c14 10uf + c14 10uf 1 2 u6 lt1086cm u6 lt1086cm vin 3 vout 2 adj 1 tab 4 bt1 battery bt1 battery 1 2 c13 0.1uf c13 0.1uf + c16 10uf + c16 10uf r28 121 ohm r28 121 ohm 1 2 j15 vbat j15 vbat 1 2 3 j17 gnd j17 gnd 1 2 3 j16 gnd j16 gnd 1 2 3 c15 0.01uf c15 0.01uf
crimzon ? development board kit pug002601-1207 page 6 of 8 figure 5. schematics (4 of 5) 5 5 4 4 3 3 2 2 1 1 d d c c b b a a row0 row1 row2 row3 row4 row5 row6 row7 col7 col6 col5 col4 col3 col2 col1 col0 col0 col1 col2 col3 col4 col5 col6 col7 p02 p04 p06 p20 p05 p22 p00 p24 p03 p27 p07 p23 p21 p25 p26 p01 row0 row7 row3 row1 row6 row4 row5 row2 row0 row1 row2 row3 row4 row5 row6 row7 col0 col1 col2 col3 col4 col5 col6 col7 p20 p21 p22 p23 p24 p25 p26 p27 p00 p01 p02 p03 p04 p05 p06 p07 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 45 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 45 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 45 monday, august 27, 2007 default all on default all on keypad sur mode sur on / tt hold power mute menu exit 0 enter select vol- vol+ recall 9 8 7 info cable vcr amp aux 4 5 6 guide ch- ch+ 3 2 1 dvd sat tv rec stop play pause rew ff av swap pip dsp on dsp mode disc tape tunner television video 1 video 2 audio test front / yellow center / red rear / green delay / blue delay up / tt off delay dn / tt on k5 k5 k42 k42 k30 k30 k9 k9 k59 k59 k20 k20 k6 k6 k56 k56 k18 k18 k45 k45 k50 k50 k8 k8 k2 k2 k63 k63 k7 k7 k33 k33 k57 k57 k11 k11 k40 k40 k44 k44 k64 k64 k25 k25 k53 k53 k32 k32 k1 k1 k62 k62 k35 k35 k48 k48 k52 k52 k15 k15 k4 k4 k34 k34 k31 k31 k26 k26 k13 k13 k49 k49 k16 k16 k39 k39 k46 k46 k58 k58 k47 k47 k12 k12 k51 k51 k29 k29 k17 k17 k54 k54 k27 k27 j19 hdr/pin 2x8 j19 hdr/pin 2x8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 k37 k37 k21 k21 k3 k3 k23 k23 k60 k60 k55 k55 k14 k14 k41 k41 k24 k24 k10 k10 k28 k28 k22 k22 k43 k43 k38 k38 k19 k19 j18 hdr/pin 2x8 j18 hdr/pin 2x8 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 k61 k61 k36 k36
crimzon ? development board kit pug002601-1207 page 7 of 8 figure 6. schematics (5 of 5) 5 5 4 4 3 3 2 2 1 1 d d c c b b a a g1 g2 g3 v1 v2 v3 v4 v5 g4 g5 v6 v7 v8 v9 v10 g6 g7 g8 g9 g10 v1 v2 v3 v4 v5 v6 v7 v8 v9 v10 g5 g6 g9 g7 g10 g8 g3 g4 g2 g1 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 55 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 55 monday, august 27, 2007 title size document number rev date: sheet of zilog inc. 6800 santa teresa blvd san jose, ca 95119 408-513-1500 website: www.zilog.com 96c1031-001g b zlf645 development board b 55 monday, august 27, 2007 hardware for u4 28pdip for u5 20pdip for u1 8pdip proto-type area footprint n_via3 via_non connect n_via3 via_non connect n_via12 via_non connect n_via12 via_non connect pro8 cap_0603 pro8 cap_0603 s5 screw s5 screw shunt7 j10/3-4 shunt7 j10/3-4 shunt24 j20/1 shunt24 j20/1 shunt15 j18/15-16 shunt15 j18/15-16 shunt8 j18/1-2 shunt8 j18/1-2 pro7 cap_0603 pro7 cap_0603 s4 standoff s4 standoff prou7a sn74lvc00 prou7a sn74lvc00 1 2 3 14 7 n_via15 via_non connect n_via15 via_non connect shunt3 j8/1-2 shunt3 j8/1-2 shunt18 j19/5-6 shunt18 j19/5-6 n_via4 via_non connect n_via4 via_non connect pro6 cap_0603 pro6 cap_0603 shunt25 j20/3 shunt25 j20/3 shunt11 j18/7-8 shunt11 j18/7-8 mh3 m hole1 mh3 m hole1 pro5 cap_0603 pro5 cap_0603 shunt21 j19/11-12 shunt21 j19/11-12 u4_conn1 u4 u4_conn1 u4 pro4 cap_0603 pro4 cap_0603 n_via5 via_non connect n_via5 via_non connect n_via18 via_non connect n_via18 via_non connect proto-type1 proto-type1 s3 standoff s3 standoff pro3 cap_0603 pro3 cap_0603 shunt6 j10/1-2 shunt6 j10/1-2 shunt14 j18/13-14 shunt14 j18/13-14 n_via11 via_non connect n_via11 via_non connect n_via6 via_non connect n_via6 via_non connect pro2 cap_0603 pro2 cap_0603 shunt5 j12/1-2 shunt5 j12/1-2 shunt2 j7/1-2 shunt2 j7/1-2 n_via14 via_non connect n_via14 via_non connect shunt17 j19/3-4 shunt17 j19/3-4 pro1 cap_0603 pro1 cap_0603 s2 standoff s2 standoff s8 screw s8 screw shunt10 j18/5-6 shunt10 j18/5-6 prou8a sn74lv05a prou8a sn74lv05a 1 2 7 14 mh2 m hole1 mh2 m hole1 n_via7 via_non connect n_via7 via_non connect n_via17 via_non connect n_via17 via_non connect shunt20 j19/9-10 shunt20 j19/9-10 shunt13 j18/11-12 shunt13 j18/11-12 s1 standoff s1 standoff n_via8 via_non connect n_via8 via_non connect u4_conn2 u4 u4_conn2 u4 soc_u1 dipsoc-4x2 soc_u1 dipsoc-4x2 s7 screw s7 screw shunt4 j19/15-16 shunt4 j19/15-16 shunt1 j2/1-2 shunt1 j2/1-2 shunt16 j19/1-2 shunt16 j19/1-2 n_via13 via_non connect n_via13 via_non connect n_via9 via_non connect n_via9 via_non connect shunt9 j18/3-4 shunt9 j18/3-4 mh1 m hole1 mh1 m hole1 n_via1 via_non connect n_via1 via_non connect shunt19 j19/7-8 shunt19 j19/7-8 shunt23 j20/2-4 shunt23 j20/2-4 s6 screw s6 screw n_via16 via_non connect n_via16 via_non connect n_via10 via_non connect n_via10 via_non connect prou9 75446 prou9 75446 1a 2 2a 7 s 1 1y 3 2y 6 clmp 5 u5_conn2 u5 u5_conn2 u5 shunt12 j18/9-10 shunt12 j18/9-10 pro10 cap_0603 pro10 cap_0603 mh4 m hole1 mh4 m hole1 n_via2 via_non connect n_via2 via_non connect holder 2xaaa bh1 holder 2xaaa bh1 u5_conn1 u5 u5_conn1 u5 n_via19 via_non connect n_via19 via_non connect pro9 cap_0603 pro9 cap_0603 n_via20 via_non connect n_via20 via_non connect shunt22 j19/13-14 shunt22 j19/13-14
crimzon ? development board kit pug002601-1207 page 8 of 8 do not use in life support life support policy zilog's products are not authorized for use as critical components in life support de vices or systems without the express prior written approval of the president and general counsel of zilog corporation. as used herein life support devices or systems are devices which (a) are intended for surgical implant into the body, or (b) support or sustain life and whose failure to perform when properly used in accordance with instructions for us e provided in the labe ling can be reasonably expected to result in a si gnificant injury to the user. a critical component is any component in a life support device or system whose failure to perform can be reasonably expected to cause the failure of the life suppor t device or system or to affect its safety or effectiveness. document disclaimer ?2007 by zilog, inc. all rights reserved. info rmation in this public ation concerning the devices, applications, or t echnology described is intended to suggest possible uses and may be superseded. zilog, inc. does not assume liability for or provide a representation of a ccuracy of the information, devices, or technology described in this document. zilog also does not assume liability for intellectual property infringement related in any manner to use of information, devices, or technology describe d herein or otherwise. the information cont ained within this document has been verified according to the general principles of electrical an d mechanical engineering. crimzon is a registered trademark of zilog, in c. all other product or service names are the property of their respective owners. warning:
|
